English中文abrasions撞壞
adequate適當
adhesive粘合
askew歪
axle車軸
bad smell臭味
base底下
bean bag豆袋
bent彎曲
blind hole盲孔
bottom底
broken皺/腐
bubble氣泡
burn mark燒焦紋
burr披鋒(金屬)
cable tire broken綁帶斷
came off脫掉
cannot close不能關
cannot free roll不能滾動
cannot free wheel輪不能順轉
cannot hold position不能保持位置cannot move不能移動
cannot open不能開
clamp mark鉗痕
cold mark合金有冷紋
color dispatch不對/不配色
color migration染色
component零配件
crack裂
dead spider/insect死蜘蛛/昆蟲decorating裝飾
deform變形
dent surface表面粗糙
dents缺口/崩口deviation偏差
difficult pull out拉出困難
dirty污漬
dull color啞色
duplicate重複的
durability耐久性
dust塵埃
eccentric中心偏位
egg crate蛋格
elastic橡筋
electro-plating black mark電鍍發黑
epoxy冷凝膠
explode /blow up爆炸
figure形態
flake剝落
flash披鋒(塑膠)
flaws裂紋
foreign paint顏油污漬fragments斷片
frayed毛邊
gap縫隙
gate縫隙
gear loose齒輪鬆
gift box grease彩盒有油脂
gloss光滑
hole not concentric孔偏心
human hair人頭發
insect hole蟲孔
int mal-function其中某一間歇性功能int non-function間歇性無功能integrity完整無缺intermittent(int)-function間歇功能
litho label貼紙
loud 大聲
mal-function其中一功能不良missing/insufficient segment漏或不足顯示missing parts漏配件
mix-color/uneven color flowing混色
mixed spot混點
non-function無功能
oxidation氧化
peeling剝落
pigments顏料
plate電鍍
plating peel off電鍍脫落
plush毛絨布
point角/點
polarity正負极
poor assembly裝配不良
poor chrome plate電鉻不良
poor electro plating電鍍不良
poor flocking搪膠植毛不良
poor function功能不良
poor heat seal熱燙不良poseable手腳能動公仔re-paint補油
rear后面
resists抵抗
rotate/spin轉動
rough粗糙
rubbing摩擦
run走了
rust生銹
scratch刮花
screen網/螢幕screw not tighten螺絲鬆
seal/stick粘合
seam線口
sewing車縫
shaft鐵輪
shape形狀
sharp edge銳邊/利邊sharp point 利角
short circun短電路shrinkage縮水
silk絲
sketch劃形狀
skin皮
slim/thin薄的
slivers裂片
small細小
smear弄髒
soft toy布類玩具soiling沾污
solder焊錫
solvent溶劑stabilize穩定
stitch 編法
strap loose皮帶鬆stress壓力
stuch粘住不能動stuff塞滿
swell膨脹
texture織物結構through hole穿孔
tight緊
torn撕爛
trap攝住/困
tread/wire線
trim打磨/修飾
tumble-sanded滾筒砂磨
un-trim不修飾
uneven不對稱
unsanded未砂磨的
unseal無粘合的
up side down方向側轉
velcro魔術貼
visual可見的
warpage變形 變曲
weld焊接
weld line夾痕
without gloss/dull color無光澤
without punch hole漏打孔
wrinkle皺摺
abrasion mark擦花
air bubble 氣泡(壓線)
arms orlegscan't hold position手或腳不能保持位置bald spot on plush長毛脫落露底
body shell broken身袋爆裂
broken head cause by hair rooting頭爆(車發不良引起) color contamination顏色混點
color deviation顏色偏差
color migration甩毛(經磨擦)
color misalignment不對稱色澤
color mismatch不配色
color unmatch顏色不對contamination mark混色
cut mark削痕
density of rooting spin count of hair頭發密度不合要求dent mark凹痕
dirt mark臟跡
doll is not fixed tightly公仔未綁穩
edge of seam fraying 布邊披口
electro plating abbades電鍍擦花
electro plating rainbow電鍍成五彩色electro plating shadow電鍍陰陽色
fabric fray纖維散口
fabric texture mismatch布料組織不對
fold mark/line摺痕/紋
foreign human hair人類頭髮
foreign liquid外來液體
foreign materials外來材料
gap縫隙
gassy (glue)膠水引至霧氣gear smooth滑牙
glue mark 膠水漬
grease mark機油漬
hair belt come off頭箍脫落
hair poor cutting 頭髮剪裁不良hairtrapped by seam頭髮夾於縫口
hair yarn is not flame retardant冷發不是防火冷high dense stitch車縫太密incorrect color 錯色
inpure plastic塑料不純
jumping stitch跳針
label peel off貼紙翹起
low dent stitch車縫太疏
material fray物料散口materials run物料走紗materials torn物料被撕爛mercury come off甩水銀
metal exposed露金屬
metal eye shell exposed out眼鐵殼外露
metal wire exposed out from plastic tube鐵線露出膠管missing stitch漏車縫
not conform to requirement不符合要求
not enough stuffing入棉不足
oil mark油漬
outfit fade公仔衫褪色
outfit shirinkage公仔衫縮水
outfit unfit公仔衫不合身outfit wet公仔衫濕
over glue膠水過多
over stuffing入棉過多
painting faded out退色
pile trapped by seam長毛夾於縫口poor brushing纖毛不良/梳發不良poor cutting剪裁不良
poor die-cast合金壓練不良poor embroidery刺繡不良
poor hair inter-lock stitching車發鎖針不良poor hair style發形差
poor heat sticking熱點不良
poor hot melting溶含不良
poor hot stamp熱燙/燙金不良
poor hot stamping 燙劃不良
poor lock stitching鎖針不良
poor booted hair車發不良
poor sewing 車縫不良
poor silk-screening絲印不良
poor sketching釘縫形狀不良
poor stitch縫合不良
poor stuffing入棉形狀不良
pucker縫邊皺起
ribbon fray 絲帶散口
rough surface表面不平滑
scratch mark刮花/劃痕
screw burst螺絲披鋒
screw came off螺絲脫落
screw rust螺絲生銹
screw unfasten螺絲未上蓋
seam allowance expose縫合/焊縫外露
seam open縫口爆開
sewing label loosen布標脫落
sewing machinery mark衣車靴痕
stitching hole 針孔
stuffing disproportion入棉比例不對稱
stuffing expose/cotton expose棉料外露
stuffing expose 露棉
the eyes can't move smoothly眨眼不良
thread trapped by seam長線夾於縫口
under glue膠水少
uneven shape形狀不對稱
uneven stuffing入棉不平衡untrimmed thread線未剪
use unmatched swatches in one boll公仔錯用不合適裁片velcro come off/magic tape come off魔術貼甩出
velcro detach魔術貼甩出
velcro position too hight/low魔術貼位置太高/太低water stain mark水痕跡
wrong assembly裝配錯誤
wrong sewing of botton,hook and loop釘錯鈕
yarn run走紗
zipper difficult to open拉鏈難開
blind nail隱頭釘
bolt螺釘
coating off on surface披覆脫落
damaged screw螺牙破損
dog spike鉤頭釘
dowel nail棗核釘
hob nail平頭釘
magnet磁鐵
nail釘子
nut螺絲帽
oval head nail半圓頭釘
oxidized金屬氧化/金屬生銹poor coating披覆不良
poor plating電鍍不良
poor welding焊接不良
screw螺絲/螺絲釘/ socket screw環頭螺絲
spike大釘
spring nail無頭釘
square nail方頭釘
staple口型釘
stub nail斷釘
un-even coating披覆不平
uneven end尾端突出upholstery nail包頭釘
with virdigris生銅綠
wrong coating color披覆顏色不對wrong diameter of steel wire直徑不符
back plate底板
bushings直身襯套
cavity凹模板
cavity retainer plate凹模托板/托板
cold slug well冷膠井
cooling line冷水管
cooling system冷卻系統
core plate击模板degating脫水白dowel pins縫釘ejecting system脫模系統ejector pins頂針ejector plate頂針板ejector retainer plate頂針托板eye bolt 螺絲圈gate水口
guide pins直身導針hot runner熱流道injection pressure排膠壓力jiffy-lock ejector pins固定頂針locating rings中心環main runner主流道mold cavity模腔
muti-cavity mold多穴模nozzle噴嘴regrind翻磨return pins回針runner流道scorch燒膠secondary runner次流道short shot短注shoulder bushings有托襯套single cavity mold單腔模spacer block凳子板special water junctions長喉嘴spring 彈簧stepped ejector pins有托頂針stop pins頂針板限針stripper bolts拉桿螺絲support pillars支柱thermal degradation熱分解
thermocouple熱偶viscosity粘度
water junctions短喉嘴
air compressor空氣壓縮機auger bit螺絲鑽頭ball bearing鋼球軸承belt輪帶bench vice抬式虎鉗broach拉槽機center punch打孔器chuck夾頭circular saw圓鋸circular saw blade圓鋸片cog齒輪compression chuck鬆緊夾頭core drill空心鑽cramp夾
disk saw輪鋸
drill鑽
drill press鑽機drilling machine鑽床driving傳動electric abrader砂輪機electric drill/hammer drill電鑽gimlet手鑽grinder砂光機grinding wheel砂輪jigsaw連線鋸jumper 長鋸
kerf鋸口
lathe車床
lathe tool車刀polisher打光機power meter電表
pulley皮帶盤punching machine二中床
race rotation空轉
radial arm saw萬能機riveting punch鉚釘打孔器roller bearing滾棒軸承rotary drill轉動鑽機rotary vice旋轉虎鉗sander砂磨機
saw blade鋸條
saw dust / soobs鋸屑/鋸末saw tooth鋸齒
saw horse鋸木機screw driver螺絲刀shifting spanner活動扳頭socket wrench套筒扳頭spanner 螺旋扳頭spring collate彈簧夾頭
t-wrench十字扳頭three-jar chuck三夾頭
tool sharper磨快器transformer變壓器tubular saw圓切鋸
two-jar chuck二夾頭
vice老虎鉗washer墊圈abnormal sound/noisy雜音antenna damaged天線爛battery cap came off電池蓋甩出battery coil over heat電池線圈發熱battery contact plate came off電池片甩出battery contact plate expose電池片外露battery contact plate loosen電池片鬆battery contact plate rust電池片生銹
battery polarity label come off電池极性指示標貼甩出battery polarity label up side down電池极性指示標貼倒轉battery spring came off電池彈簧甩出
battery spring expose 電池彈簧击出
battery spring loosen電池彈簧鬆
battery without power電池沒有電
cassette door poor assy卡式機門裝配不良circuit board damage電路板壞/斷路
circuit board loosen電路板鬆/斷路
circuit board non-function電路板無功能
electric leakage漏電
electric toy電動玩具
frequency weak頻率弱
hot melt insufficient熱熔膠不足intermittent(int)-function間歇功能
intermittent non-function間歇無功能
light bule without light燈泡不亮
missing battery cover漏電池蓋
missing protect tape漏保護膠貼
missing screw漏螺絲
nal-function其中某一功能不良
no sound無聲音
non-function無功能
poor contact接觸不良
poor function功能不良
poor soldering焊錫不足
poor switch開關不良
resin mark鬆香漬
short circuit斷電路
small sound小聲音/細聲音
sound too loud大聲音
switch int non-function開關間歇無功能switch non-function開關無功能
switch too loosen摯鬆
switch too tight摯緊
too tight when turning the key摯轉動時太緊
watch belt loosen表帶鬆
wire detach電線甩出
wire expose 電線击出
wire poor welding電線焊接不良without completed display/fade出現不整顯示without display無顯示
abrasion mark from mold模具磨傷
abs/ acrylonitrile-butadience-styrene有毒的一種不碎膠bittleness脆
bs/ buadiene styren bs料
bubble inside plastic原料中有氣泡
bump/scratched mark碰傷/刮傷
ca/ cellulose acetate酸性膠
chipped有缺口
cn/ cellulose nitrate賽璐
color shade different色差
broken/crack破損,斷裂/裂痕damage by mold release脫膠
deformed變形
degraded material水口料
dirty stain雜質污點(外在) ejector mark頂針位
easy broken (too much used material in)易脆裂(次料摻入太多) embedded dirty雜質污點(內在)
eva/ ethylene-vinyl acetate copolymer橡皮膠
excessive flash大披鋒
excessive or unpleasant odour容器內有怪味
flow line/mark夾水紋/痕
foreign matter in外物殘留
gate remnant水口
ggps/ general purpose polystyene普通硬膠
hdpe/ high density polyethylene高密軟膠
hips/ high impact polystyrene高沖擊硬膠
ldpe/ low density polyethylene低密軟膠
impurity spot mixed in material水痕
mms/ methyl methactylate butadtiene 改性有機玻璃
oil mark油污
over cut毛邊修整過多
pa/ polyamide尼龍類
part line夾模線
part line misalignment夾模線離位
pc/ polycartbonate防彈膠
pear skin沙梨皮/(搪膠)
pet/ polyethylene terephthalate聚酯
pf/ phenol-formaldehyde電木粉
plastic remnant膠碎未清/殘餘
plastic residue膠絲碎
plastic toys塑膠玩具
pmma/ polymethyl methacrylate亞加力
pom/ polyoxy-methylene resin賽鋼
poor lamination披膜不良
poor rotocasting搪膠不良
poor sonic weld超聲不良
poor transparency透明度不良
poor trimming毛邊未修齊
poor welding超聲不良/電鍍不良
pp/ polypropylene百析膠/pp
pu/ polyurethane pu
pvc/ polyvinyl chloride resin pvc
rotacast too thin搪膠薄
san/ styrene-acrylonitrile copolymer san料
sharp flash point 射出點尖銳
sharp edge邊緣尖銳
short shot/undershot走料不到/足(射出不足) shot壓練出來
shirink mark/shrin kage縮水
sink mark/dent凹陷痕
si/ silicone硅樹脂
solvent mark溶劑印
sonic weld超聲
stress mark泛白
under cooked plastic 生膠
uneven wall thickness膠件厚度不平均untrimmed at rim毛邊未修untrimmed flash point射出點未修平void穿孔
weld line夾水印
blurred印刷不清楚discoloration顏色不均lacquer accumulation聚漆
over spraying飛油
paint涂油
paint abrades噴油擦花
paint accumulation聚油
painting噴漆
painting scratched off刮甩油
poor printing印刷不良
poor spraying噴油不良
poor tempo/ poor silkprint絲印不良
print印刷
under spraying噴油不足uneven spraying厚薄不均噴油alder赤陽木antiseptic防腐
banding木材扭曲
bad smell有怪味
bark剝披
beech櫸木
bending彎曲度
birch樺木
bisect平分為二broken strap捆扎中有斷裂者burr毛口
chip木屑
closed-pore密閉氣孔coarse grain粗紋
cork軟木
cross grain斜紋
curly grain卷紋
dirt stain beform lacquer上光前粘有污漬distort歪曲/扭曲/變形encased know暗節
even grain均紋
excelsior刨花fiberwood纖維板
fine grain細紋
gnarl木節
grain木紋
hair out須邊突出
hard maple硬楓木hardness硬度
hickory山胡桃木
kiln drying烘乾
knothole節疤/孔
knotty多節
left over殘料
loose strand緊密度不足moisture not meet requirement干燥度不足mottled grain斑紋
musty發霉
noggin piece木筋
peg木釘
plywood夾板
poor lacquer上光不良
poplar白楊木
rotten wood腐木
rubber tree橡膠木
sap gum楓香邊材
sapwood邊材
shape distorted形狀走樣
too many nodes than aproved sample材料節部太多
variation of color on材料雜色太多
wrong size尺寸不對
assortment pack混合裝
bilingual pack兩種語言的包裝(說明書) blister card damage吸塑卡爛
blister card poor die-cut吸塑卡剪裁不良
blister card wet吸塑卡濕水
blister card wrinkle吸塑卡皺
blister card wrong die-cut吸塑卡剪裁錯誤
blister crack吸塑卡裂
blister crushed吸塑卡壓凹
blister damage吸塑爛
blister deform吸塑變形
blister detach吸塑甩開
blister detached from card 吸塑罩不穩/易甩開blister loose off吸塑罩鬆
blister pack吸塑包裝
blister poor heat sealing吸塑不良
blister shrinkage吸塑縮水
blister undershot吸塑走料
blister unseal吸塑不粘
bulk pack散裝
burn mark on blister吸塑燒焦
burn mark on blister card吸塑卡燒焦
butterfly hook蝴蝶孔
butterfly hook damage蝴蝶孔爛
butterfly hook poor die-cut蝴蝶孔剪裁不良
butterfly hook wrinkle蝴蝶孔皺butterfly hook wrong die-cut蝴蝶孔剪裁錯誤cable tie結束帶
carton glue tape loose大箱封箱紙鬆carton mark illegible大箱箱印模糊color box crumple彩盒弄皺
color box crushed彩盒壓爛/壓皺color box deform彩盒變形
color box flap seam open彩盒縫口爆開color box illegible彩盒濛
color box pack彩盒裝
color box wet彩盒濕
color box window sheet dirty彩盒玻璃窗髒污date code illegible日期印濛
dent mark on window box film彩盒膠窗有凹痕display box pack開口彩盒裝euro-slot size wrong蝴蝶洞尺寸不對fold mark on bilster card吸塑卡有折痕foreign matter trapped in blister泡殼中夾有雜物hang tag吊卡
header 頭卡
heat sealed broken熱封口破裂incorrect assortment pack混裝之數目不符incorrect blister爛 j-形勾incorrect blister card皺 j-形卡incorrect color box用錯彩盒incorrect polybag用錯塑膠袋inner carton內箱
insert card內卡
insert damaged內卡爛instruction sheet說明書instruction sheet illegible說明書濛
j-hook sticker j-形勾貼
j-hook j-形勾
j-hook damage j-形勾爛
j-hook poor die-cut j-形勾剪裁不良
label sticking improperly招貼粘貼不良
master carton外箱
missing component漏零配件
missing date code 漏日期印
missing parts漏裝配件
missing warning word on polybag塑膠袋未加警語missing whole pack of accessory漏整包配件
outer over weight外箱超重
poor heat sealing熱封不良
poor heat sealing blister泡殼熱熔不夠緊密poor printing印刷不良
poor print registration套印不良
poor label adhensived標籤粘貼不良polybag damage膠袋爛
polybag material not meet requirement塑膠袋材料不正確polybag not by upside down塑膠袋套入不正確polybag outstep to euro-slot塑膠袋超出蝴蝶洞polybag without punch未加打通氣孔
sealing tape not properly膠紙粘貼不良
shirink wrap收縮包裝
shirink wrap broken 收縮包裝破裂
shirink wrap loose收縮包裝太鬆
soft corrugated carton外箱太簿
solid pack獨立裝
sticker貼紙
story book illegible故事書濛
styrofoam dirty發泡膠污濁
use non-peelable label未使用可重覆使用標貼white mark on window box film彩盒膠窗發白
whole pack整包
window box film damage彩盒膠窗爛
window box film detach彩盒膠窗脫落
window box film poor sealing彩盒膠窗粘貼不良window box film poor transparency彩盒膠窗透明度不良window box film stress彩盒膠窗預白window box pack有膠窗彩盒裝
wire tie鐵線扎帶
wrong assorted數量混裝不正確wrong quantity packed in數量不對
color thread trapped inside有色線被包入
fabric fault布料瑕疵
fabric frayed布料磨破
hole in fabric布有破洞
loose stitches斷線
needle chew line吃線
open seam車縫處繃開skipped stitch車縫跳針untrimmed thread end線頭未修整
black spot 黑點
clay lump under glazed釉有突出物
foreign matter stuck on surface外物附著於表面impurities陶土中有雜質
pin hole針孔
pimple粉刺
poor glazing上釉不良
smeared painting彩繪污點
uneven glazing 上釉不均勻unsmooth surface表面不平滑contamination有污染物
detached parts零件脫落
improper assembly裝配不緊malfunctuion無功能
missing parts零配件短缺
not close properly無法密合
poor assembly裝配不良
poor screening網版印刷不良
rivet damaged鉚釘損壞water leakage漏水wobbled base搖晃不平